 |
|||
|
|
|||
|
|
|||
| ||||||||||
|
|
 TM 9-2320-386-10
3-2. GENERAL (Contd)
WARNING
Operation of a deadlined vehicle, without preliminary
inspection, may cause injury to personnel and/or damage
to equipment.
Hearing protection is required for the driver and
co-driver. Hearing protection is also required for all
personnel working in and around this vehicle while the
engine is running (reference AR 40-5 and TB MED 501).
NOTE
Operators should perform the corrective action in the
order listed until the malfunction is corrected. If none of
the steps correct the malfunction, notify unit maintenance.
b. Omissions. This manual cannot list all malfunctions that may occur. If a
malfunction occurs that is not listed in table 3-1, notify unit maintenance.
c. Symptom Index. To find a specific malfunction, refer to the symptom index.
TROUBLESHOOTING
MALFUNCTION
MALFUNCTION
PROCEDURE
NO.
PAGE
ENGINE
1.
Engine starter switch is engaged but engine fails to start . . . . .
....
2.
Engine cranks but does not start . . . . . . . . . . . . . . . . . . . . . . .
....
3.
Engine cranks but fails to start at outside temperatures
below 0F (-18C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
....
4.
Engine starts but misfires, runs rough, or lacks power . . . . . . .
....
5.
Engine overheats as indicated by engine coolant
temperature gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
....
6.
Low engine oil pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
....
7.
Excessive exhaust smoke after engine reaches normal operating
temperature of 160F to 230F (71C to 110C) . . . . . . . . . . .
....
TRANSMISSION
8.
No response to gear shift lever movement . . . . . . . . . . . . . . . .
....
9.
Rough shifting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
....
10.
Lubricant leakage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
....
TRANSFER CASE
11.
Transfer case shift lever will not shift or slips
out of gear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
....
12.
Transfer case lubricant leakage. . . . . . . . . . . . . . . . . . . . . . . .
....
FRONT AND REAR AXLES
13.
Front axle is noisy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
....
14.
Rear axle is noisy. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
....
3-2
|
|
Privacy Statement - Press Release - Copyright Information. - Contact Us |
Click
here for thousands of PDF manuals