TM-9-2350-238-20-1

• TECHNICAL MANUAL
• Warning
• Warning (Cont)
• Warning (Cont)
• Warning (Cont)
• Table of Contents
• Table of Contents (Cont)
• M578 Recovery Vehicle
• Chapter 1. INTRODUCTION
• PREPARATION FOR STORAGE OR SHIPMENT.
• REPORTING EQUIPMENT IMPROVEMENT RECOMMENDATIONS (EIR)
• Section Il. EQUIPMENT DESCRIPTION AND DATA
• M578 Recovery Vehicle-Electrical Components
• LOCATION AND DESCRIPTION OF MAJOR COMPONENTS
• Exhaust System
• FUEL SYSTEM
• GAS-PARTICULATE FILTER
• POWERPLANT
• COOLING SYSTEM
• AUXILIARY DRIVE ASSEMBLY
• AIR INTAKE SYSTEM
• SPECIAL PURPOSE KITS
• EQUIPMENT DATA.
• Air Intake System.
• Tracks and Suspension.
• Section Ill. PRINCIPLES OF OPERATION
• Chapter 2. UNIT MAINTENANCE INSTRUCTIONS
• CHAPTER INDEX
• CHAPTER INDEX (Cont)
• CHAPTER INDEX (Cont)
• CHAPTER INDEX (Cont)
• CHAPTER INDEX (Cont)
• Section 1. REPAIR PARTS, SPECIAL TOOLS, TMDE, AND SUPPORT EQUIPMENT
• Table 2-1. SERVICE UPON RECEIPT--M578 RECOVERY VEHICLE
• Table 2-1. SERVICE UPON RECEIPT--M578 RECOVERY VEHICLE (Cont)
• Table 2-1. SERVICE UPON RECEIPT--M578 RECOVERY VEHICLE (Cont)
• Table 2-1. SERVICE UPON RECEIPT--M578 RECOVERY VEHICLE (Cont)
• Table 2-1. SERVICE UPON RECEIPT--M578 RECOVERY VEHICLE (Cont)
• Section Ill. UNIT PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) AND LUBRICATION INSTRUCTIONS
• GENERAL PROCEDURES.
• Services
• TOOLS AND SUPPLIES.
• MANDATORY REPLACEMENT PARTS
• LUBRICANT TABLE
• LUBRICANT TABLE (Cont)
• LUBRICANT TABLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Table 2-2. PREVENTIVE MAINTENANCE CHECKS AND SERVICES WITH LUBRICATION INSTRUCTIONS FOR M578 RECOVERY VEHICLE (Cont)
• Section IV. UNIT TROUBLESHOOTING
• TROUBLESHOOTING INFORMATION
• TROUBLESHOOTING INFORMATION (Cont)
• TROUBLESHOOTING INFORMATION (Cont)
• TROUBLESHOOTING INFORMATION (Cont)
• Table 2-3. UNIT TROUBLESHOOTING
• ENGINE DOES NOT CRANK.
• ENGINE CRANKS SLOWLY AND LIGHTS DIM WHILE CRANKING.
• ENGINE CRANKS BUT DOES NOT START; AND ELECTRICAL CIRCUITS ARE OPERATING
• ENGINE CRANKS BUT DOES NOT START; AND ELECTRICAL CIRCUITS ARE OPERATING (Cont)
• ENGINE DOES NOT DEVELOP FULL POWER, RUNS UNEVENLY, STALLS, OR LABORS.
• ENGINE DOES NOT DEVELOP FULL POWER, RUNS UNEVENLY, STALLS, OR LABORS. (Cont)
• ENGINE OVERHEATS.
• EXCESSIVE EXHAUST SMOKE (BLACK SMOKE) AFTER ENGINE WARMUP.
• EXCESSIVE EXHAUST SMOKE (WHITE SMOKE) AFTER ENGINE WARMUP.
• ENGINE HAS HIGH OIL PRESSURE.
• COOLING SYSTEM
• GENERATOR DOES NOT OPERATE
• ELECTRICAL--BATTERY POWER
• GENERATOR COOLING FAN DOES NOT OPERATE.
• BATTERY-GENERATOR INDICATOR IS IN RED AND GENERATOR IS OVERCHARGING.
• ELECTRICAL--INDICATORS
• SPEEDOMETER OR TACHOMETER NEEDLE DOES NOT MOVE, IS NOT STEADY, OR DOES NOT READ CORRECTLY.
• ELECTRICAL--WARNING LIGHTS AND HORN
• SUSPENSION LOCKED WARNING LIGHT IS OFF AND SUSPENSION IS IN LOCKED POSITION
• ELECTRICAL--WARNING HORN AND AERATION DETECTOR
• ELECTRICAL--TRAILER RECEPTACLE
• ELECTRICAL--BLACKOUT MARKER
• ELECTRICAL--LIGHTS
• ELECTRICAL--DRIVER'S COMPARTMENT DOME LIGHT
• ELECTRICAL--MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT
• ELECTRICAL--AIR BOX HEATER
• OIL PRESSURE IS TOO LOW.
• VEHICLE DOES NOT STOP PROPERLY.
• AUXILIARY DRIVE AND POWER TAKEOFF
• AUXILIARY DRIVE OR POWER TAKEOFF MAKES TOO MUCH NOISE.
• TRACKS AND SUSPENSION
• VEHICLE THROWS TRACK OR TRACK JUMPS SPROCKET TEETH.
• LOCKOUT CYLINDERS DO NOT LOCK WHEN SUSP LOCKED/UNLOCKED VALVE IS TURNED TO LOCKED.
• VEHICLE DOES NOT STEER PROPERLY.
• VEHICLE DOES NOT STOP PROPERLY.
• HYDRAULIC SUSPENSION LOCKOUT CYLINDER ASSEMBLY
• HYDRAULIC SUSPENSION LOCKOUT CYLINDER ASSEMBLY DOES NOT UNLOCK.
• SPADE
• HEATER INSTALLATION KIT
• DRIVER'S HEATER CONTROL BOX LIGHT DOES NOT OPERATE WHEN PRESS- TESTED
• DRIVER'S WINDSHIELD ENCLOSURE KIT
• FIXED FIRE EXTINGUISHER
• ELECTRICAL CIRCUIT TROUBLESHOOTING.
• ELECTRICAL CIRCUIT SYMPTOM INDEX
• ELECTRICAL CIRCUIT SYMPTOM INDEX (Cont)
• BATTERY POWER CIRCUIT.
• BATTERY POWER CIRCUIT. (Cont)
• BATTERY POWER CIRCUIT. (Cont)
• MASTER SWITCH CIRCUIT.
• MASTER SWITCH CIRCUIT. (Cont)
• MASTER SWITCH CIRCUIT. (Cont)
• MASTER SWITCH CIRCUIT. (Cont)
• MASTER SWITCH CIRCUIT. (Cont)
• MASTER RELAY CIRCUIT.
• MASTER RELAY CIRCUIT. (Cont)
• MASTER RELAY CIRCUIT. (Cont)
• MASTER RELAY CIRCUIT. (Cont)
• MASTER RELAY CIRCUIT. (Cont)
• MASTER RELAY CIRCUIT. (Cont)
• MASTER RELAY CIRCUIT. (Cont)
• MASTER RELAY CIRCUIT. (Cont)
• INSTRUMENT SWITCH CIRCUIT.
• INSTRUMENT SWITCH CIRCUIT. (Cont)
• INSTRUMENT SWITCH CIRCUIT. (Cont)
• INSTRUMENT SWITCH CIRCUIT. (Cont)
• INSTRUMENT SWITCH CIRCUIT. (Cont)
• STARTER CIRCUITS.
• STARTER CIRCUITS. (Cont)
• STARTER CIRCUITS. (Cont)
• STARTER CIRCUITS. (Cont)
• STARTER CIRCUITS. (Cont)
• STARTER CIRCUITS. (Cont)
• STARTER CIRCUITS. (Cont)
• STARTER CIRCUITS. (Cont)
• AIR CLEANER BLOWER CIRCUIT.
• AIR CLEANER BLOWER CIRCUIT. (Cont)
• AIR CLEANER BLOWER CIRCUIT. (Cont)
• AIR CLEANER BLOWER CIRCUIT. (Cont)
• GENERATOR COOLING FAN CIRCUIT.
• GENERATOR COOLING FAN CIRCUIT. (Cont)
• GENERATOR COOLING FAN CIRCUIT. (Cont)
• GENERATOR COOLING FAN CIRCUIT. (Cont)
• GENERATOR COOLING FAN CIRCUIT. (Cont)
• GENERATOR COOLING FAN CIRCUIT. (Cont)
• GENERATOR OUTPUT CIRCUIT.
• GENERATOR OUTPUT CIRCUIT. (Cont)
• GENERATOR OUTPUT CIRCUIT. (Cont)
• GENERATOR OUTPUT CIRCUIT. (Cont)
• GENERATOR OUTPUT CIRCUIT. (Cont)
• GENERATOR-REGULATOR CHARGING CIRCUIT TEST.
• GENERATOR CHARGING CIRCUIT.
• GENERATOR CHARGING CIRCUIT. (Cont)
• GENERATOR CHARGING CIRCUIT. (Cont)
• GENERATOR CHARGING CIRCUIT. (Cont)
• GENERATOR CHARGING CIRCUIT. (Cont)
• GENERATOR CHARGING CIRCUIT. (Cont)
• GENERATOR CHARGING CIRCUIT. (Cont)
• GENERATOR CHARGING CIRCUIT. (Cont)
• GENERATOR CHARGING CIRCUIT. (Cont)
• BATTERY-GENERATOR INDICATOR CIRCUIT.
• BATTERY-GENERATOR INDICATOR CIRCUIT. (Cont)
• ENGINE OIL PRESSURE INDICATOR CIRCUIT.
• ENGINE OIL PRESSURE INDICATOR CIRCUIT. (Cont)
• ENGINE OIL PRESSURE INDICATOR CIRCUIT. (Cont)
• ENGINE OIL PRESSURE INDICATOR CIRCUIT. (Cont)
• ENGINE COOLANT TEMPERATURE INDICATOR CIRCUIT.
• ENGINE COOLANT TEMPERATURE INDICATOR CIRCUIT. (Cont)
• ENGINE COOLANT TEMPERATURE INDICATOR CIRCUIT. (Cont)
• ENGINE COOLANT TEMPERATURE INDICATOR CIRCUIT. (Cont)
• TRANSMISSION OIL PRESSURE INDICATOR CIRCUIT.
• TRANSMISSION OIL PRESSURE INDICATOR CIRCUIT. (Cont)
• TRANSMISSION OIL PRESSURE INDICATOR CIRCUIT. (Cont)
• TRANSMISSION OIL TEMPERATURE INDICATOR CIRCUIT.
• TRANSMISSION OIL TEMPERATURE INDICATOR CIRCUIT. (Cont)
• TRANSMISSION OIL TEMPERATURE INDICATOR CIRCUIT. (Cont)
• TRANSMISSION OIL TEMPERATURE INDICATOR CIRCUIT. (Cont)
• FUEL LEVEL INDICATOR CIRCUIT.
• FUEL LEVEL INDICATOR CIRCUIT. (Cont)
• FUEL LEVEL INDICATOR CIRCUIT. (Cont)
• FUEL LEVEL INDICATOR CIRCUIT. (Cont)
• FUEL LEVEL INDICATOR CIRCUIT. (Cont)
• FUEL LEVEL INDICATOR CIRCUIT. (Cont)
• MASTER INDICATOR WARNING LIGHT CIRCUIT.
• MASTER INDICATOR WARNING LIGHT CIRCUIT. (Cont)
• MASTER INDICATOR WARNING LIGHT CIRCUIT. (Cont)
• MASTER INDICATOR WARNING LIGHT CIRCUIT. (Cont)
• SUSPENSION LOCKED WARNING LIGHT CIRCUIT.
• SUSPENSION LOCKED WARNING LIGHT CIRCUIT. (Cont)
• GENERATOR WARNING LIGHT CIRCUIT.
• GENERATOR WARNING LIGHT CIRCUIT. (Cont)
• GENERATOR WARNING LIGHT CIRCUIT. (Cont)
• GENERATOR WARNING LIGHT CIRCUIT. (Cont)
• GENERATOR WARNING LIGHT CIRCUIT. (Cont)
• GENERATOR WARNING LIGHT CIRCUIT. (Cont)
• GENERATOR WARNING LIGHT CIRCUIT. (Cont)
• WARNING HORN RELAY.
• WARNING HORN CIRCUIT.
• WARNING HORN CIRCUIT. (Cont)
• WARNING HORN CIRCUIT. (Cont)
• WARNING SWITCH CIRCUIT.
• WARNING SWITCH CIRCUIT. (Cont)
• WARNING SWITCH CIRCUIT. (Cont)
• WARNING SWITCH CIRCUIT. (Cont)
• WARNING SWITCH CIRCUIT. (Cont)
• WARNING SWITCH CIRCUIT. (Cont)
• ENGINE-XMSN TEMP-PRESS WARNING LIGHT CIRCUIT.
• ENGINE-XMSN TEMP-PRESS WARNING LIGHT CIRCUIT. (Cont)
• ENGINE-XMSN TEMP-PRESS WARNING LIGHT CIRCUIT. (Cont)
• ENGINE-XMSN TEMP-PRESS WARNING LIGHT CIRCUIT. (Cont)
• ENGINE-XMSN TEMP-PRESS WARNING LIGHT CIRCUIT. (Cont)
• WARNING HORN AND ENGINE-XMSN TTEMP-PRESS WARNING LIGHT CIRCUIT.
• WARNING HORN AND ENGINE-XMSN TTEMP-PRESS WARNING LIGHT CIRCUIT. (Cont)
• AERATION DETECTOR CIRCUIT.
• AERATION DETECTOR CIRCUIT. (Cont)
• AERATION DETECTOR CIRCUIT. (Cont)
• AERATION DETECTOR CIRCUIT. (Cont)
• AERATION DETECTOR CIRCUIT. (Cont)
• SERVICE HEADLAMP, TAILLIGHT, AND STOPLIGHT CIRCUIT.
• SERVICE HEADLAMP, TAILLIGHT, AND STOPLIGHT CIRCUIT. (cont)
• SERVICE HEADLAMP, TAILLIGHT, AND STOPLIGHT CIRCUIT. (cont)
• SERVICE HEADLAMP, TAILLIGHT, AND STOPLIGHT CIRCUIT. (cont)
• SERVICE HEADLAMP, TAILLIGHT, AND STOPLIGHT CIRCUIT. (cont)
• SERVICE HEADLAMP, TAILLIGHT, AND STOPLIGHT CIRCUIT. (cont)
• SERVICE HEADLAMP, TAILLIGHT, AND STOPLIGHT CIRCUIT. (cont)
• SERVICE HEADLAMP CIRCUIT (LOW BEAM).
• SERVICE HEADLAMP CIRCUIT (LOW BEAM). (Cont)
• SERVICE HEADLAMP CIRCUIT (LOW BEAM). (Cont)
• SERVICE HEADLAMP CIRCUIT (HI BEAM).
• SERVICE HEADLAMP CIRCUIT (HI BEAM). (Cont)
• SERVICE HEADLAMP CIRCUIT (HI BEAM). (Cont)
• SERVICE HEADLAMP CIRCUIT (LEAD 17).
• SERVICE HEADLAMP CIRCUIT (LEAD 17). (Cont)
• SERVICE HEADLAMP CIRCUIT (LEAD 18).
• SERVICE HEADLAMP CIRCUIT (LEAD 18). (Cont)
• HI BEAM IND LIGHT CIRCUIT.
• HI BEAM IND LIGHT CIRCUIT. (Cont)
• HI BEAM IND LIGHT CIRCUIT. (Cont)
• HI BEAM IND LIGHT CIRCUIT. (Cont)
• LEFT STOPLIGHT-TAILLIGHT CIRCUIT.
• LEFT STOPLIGHT-TAILLIGHT CIRCUIT. (Cont)
• LEFT STOPLIGHT-TAILLIGHT CIRCUIT. (Cont)
• LEFT STOPLIGHT-TAILLIGHT CIRCUIT. (Cont)
• LEFT STOPLIGHT-TAILLIGHT CIRCUIT. (Cont)
• TRAILER RECEPTACLE CIRCUIT.
• TRAILER RECEPTACLE CIRCUIT. (Cont)
• TRAILER RECEPTACLE CIRCUIT. (Cont)
• BLACKOUT MARKER CIRCUIT.
• BLACKOUT MARKER CIRCUIT. (Cont)
• BLACKOUT MARKER CIRCUIT. (Cont)
• BLACKOUT MARKER CIRCUIT. (Cont)
• BLACKOUT MARKER CIRCUIT. (Cont)
• TAILLIGHT BLACKOUT MARKER CIRCUIT.
• TAILLIGHT BLACKOUT MARKER CIRCUIT. (Cont)
• TAILLIGHT BLACKOUT MARKER CIRCUIT. (Cont)
• HEADLAMP BLACKOUT MARKER CIRCUIT.
• HEADLAMP BLACKOUT MARKER CIRCUIT. (Cont)
• BLACKOUT DRIVE HEADLAMP CIRCUIT (VEHICULAR LIGHT SWITCH).
• BLACKOUT DRIVE HEADLAMP CIRCUIT (VEHICULAR LIGHT SWITCH). (Cont)
• BLACKOUT DRIVE HEADLAMP CIRCUIT (HEADLAMP ASSEMBLY).
• BLACKOUT DRIVE HEADLAMP CIRCUIT (HEADLAMP ASSEMBLY). (Cont)
• BLACKOUT DRIVE HEADLAMP CIRCUIT (HEADLAMP ASSEMBLY). (Cont)
• BLACKOUT STOPLIGHT CIRCUIT.
• BLACKOUT STOPLIGHT CIRCUIT. (Cont)
• BLACKOUT STOPLIGHT CIRCUIT. (Cont)
• BLACKOUT STOPLIGHT CIRCUIT. (Cont)
• TRAILER RECEPTACLE BLACKOUT CIRCUIT.
• TRAILER RECEPTACLE BLACKOUT CIRCUIT. (Cont)
• TRAILER RECEPTACLE BLACKOUT CIRCUIT. (Cont)
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (B0-1R AND VEHICULAR LIGHT SWITCHES)
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (B0-1R AND VEHICULAR LIGHT SWITCHES) (Cont)
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (B0-1R AND VEHICULAR LIGHT SWITCHES) (Cont)
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (B0-1R AND VEHICULAR LIGHT SWITCHES) (Cont)
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (HEADLAMP DIMMER SWITCH).
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (HEADLAMP DIMMER SWITCH). (Cont)
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (LEAD 515).
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (LEAD 515). (Cont)
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (LEAD 514).
• SERVICE BLACKOUT (INFRARED) HEADLAMP CIRCUIT (LEAD 514). (Cont)
• HI BEAM IND LIGHT (BLACKOUT) CIRCUIT.
• HI BEAM IND LIGHT (BLACKOUT) CIRCUIT. (Cont)
• HI BEAM IND LIGHT (BLACKOUT) CIRCUIT. (Cont)
• INSTRUMENT (SWITCH) PANEL LIGHT CIRCUIT.
• INSTRUMENT (SWITCH) PANEL LIGHT CIRCUIT. (Cont)
• DRIVER'S COMPARTMENT DOME LIGHT CIRCUIT.
• DRIVER'S COMPARTMENT DOME LIGHT CIRCUIT. (Cont)
• UTILITY OUTLET CIRCUIT.
• UTILITY OUTLET CIRCUIT. (Cont)
• UTILITY OUTLET CIRCUIT. (Cont)
• UTILITY OUTLET CIRCUIT. (Cont)
• UTILITY OUTLET CIRCUIT. (Cont)
• MAGNETIC CLUTCH AND BYPASS SOLENOID CIRCUIT.
• MAGNETIC CLUTCH AND BYPASS SOLENOID CIRCUIT. (Cont)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (HYD PUMP/PTO CLUTCH SWITCH)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (HYD PUMP/PTO CLUTCH SWITCH) (Cont)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (HYD PUMP/PTO CLUTCH SWITCH) (Cont)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (HYD PUMP/PTO CLUTCH SWITCH) (Cont)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (MAGNETIC CLUTCH).
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (MAGNETIC CLUTCH). (Cont)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (MAGNETIC CLUTCH). (Cont)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (MAGNETIC CLUTCH). (Cont)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (BYPASS SOLENOID VALVE)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (BYPASS SOLENOID VALVE) (Cont)
• MAGNETIC CLUTCH AND BYPASS SOLENOID VALVE CIRCUIT (BYPASS SOLENOID VALVE) (Cont)
• AIR BOX HEATER CIRCUIT.
• AIR BOX HEATER CIRCUIT. (Cont)
• AIR BOX HEATER CIRCUIT. (Cont)
• AIR BOX HEATER CIRCUIT. (Cont)
• AIR BOX HEATER CIRCUIT. (Cont)
• AIR BOX HEATER.
• AIR BOX HEATER. (Cont)
• AIR BOX HEATER. (Cont)
• AIR BOX HEATER. (Cont)
• AIR BOX HEATER. (Cont)
• AIR BOX HEATER. (Cont)
• AIR BOX HEATER. (Cont)
• FUEL FILTER HEATER CIRCUIT.
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• FUEL FILTER HEATER CIRCUIT. (Cont)
• AIR INTAKE FAN AND SOLENOID CIRCUIT.
• AIR INTAKE FAN AND SOLENOID CIRCUIT. (Cont)
• AIR INTAKE FAN AND SOLENOID CIRCUIT. (Cont)
• AIR INTAKE FAN AND SOLENOID CIRCUIT. (Cont)
• AIR INTAKE FAN AND SOLENOID CIRCUIT. (Cont)
• AIR INTAKE FAN AND SOLENOID CIRCUIT. (Cont)
• AIR INTAKE FAN AND SOLENOID CIRCUIT. (Cont)
• AIR INTAKE FAN AND SOLENOID CIRCUIT. (Cont)
• AIR INTAKE FAN AND SOLENOID CIRCUIT. (Cont)
• COOLANT HEATER CONTROL BOX LIGHT CIRCUIT.
• COOLANT HEATER CONTROL BOX LIGHT CIRCUIT. (Cont)
• COOLANT HEATER CONTROL BOX LIGHT CIRCUIT. (Cont)
• COOLANT HEATER CONTROL BOX LIGHT CIRCUIT. (Cont)
• COOLANT HEATER CIRCUIT.
• COOLANT HEATER CIRCUIT. (Cont)
• COOLANT HEATER CIRCUIT. (Cont)
• DRIVER'S HEATER CONTROL BOX LIGHT CIRCUIT.
• DRIVER'S HEATER CONTROL BOX LIGHT CIRCUIT. (Cont)
• DRIVER'S HEATER CONTROL BOX LIGHT CIRCUIT. (Cont)
• DRIVER'S HEATER FUEL PUMP CIRCUIT.
• DRIVER'S HEATER FUEL PUMP CIRCUIT. (Cont)
• DRIVER'S HEATER FUEL PUMP CIRCUIT. (Cont)
• DRIVER'S HEATER FUEL PUMP CIRCUIT. (Cont)
• DRIVER'S HEATER CIRCUIT.
• DRIVER'S HEATER CIRCUIT. (Cont)
• DRIVER'S HEATER CIRCUIT. (Cont)
• DRIVER'S HEATER CIRCUIT. (Cont)
• PYROMETER CIRCUIT.
• PYROMETER CIRCUIT. (Cont)
• WINDSHIELD WIPER CIRCUIT.
• WINDSHIELD WIPER CIRCUIT. (Cont)
• WINDSHIELD WIPER CIRCUIT. (Cont)
• WINDSHIELD WIPER CIRCUIT. (Cont)
• WINDSHIELD DEFROSTER CIRCUIT.
• WINDSHIELD DEFROSTER CIRCUIT. (Cont)
• WINDSHIELD DEFROSTER CIRCUIT. (Cont)
• WINDSHIELD DEFROSTER CIRCUIT. (Cont)
• WINDSHIELD DEFROSTER CIRCUIT. (Cont)
• WINDSHIELD DEFROSTER CIRCUIT. (Cont)
• OIL RESERVOIR HEATER KIT.
• OIL RESERVOIR HEATER KIT. (Cont)
• OIL RESERVOIR HEATER KIT. (Cont)
• OIL RESERVOIR HEATER KIT. (Cont)
• PERSONNEL HEATER CONTROL BOX LIGHT CIRCUIT.
• PERSONNEL HEATER CONTROL BOX LIGHT CIRCUIT. (Cont)
• PERSONNEL HEATER CONTROL BOX LIGHT CIRCUIT. (Cont)
• PERSONNEL HEATER CIRCUIT.
• PERSONNEL HEATER CIRCUIT. (Cont)
• PERSONNEL HEATER CIRCUIT. (Cont)
• DRIVER'S AIR PURIFIER CIRCUIT.
• DRIVER'S AIR PURIFIER CIRCUIT. (Cont)
• DRIVER'S AIR PURIFIER CIRCUIT. (Cont)
• DRIVER'S AIR PURIFIER CIRCUIT. (Cont)
• DRIVER'S AIR PURIFIER CIRCUIT. (Cont)
• DRIVER'S AIR PURIFIER CIRCUIT. (Cont)
• Section V. WIRING HARNESS AND CABLE REPAIR
• DISASSEMBLY
• TYPICAL FEMALE-TYPE PANEL MOUNTING RECEPTACLE CONNECTOR.
• TYPICAL FEMALE-TYPE PLUG CONNECTOR.
• TYPICAL MALE-TYPE PLUG CONNECTOR.
• REPLACING CABLE TERMINALS AND SHELL CONNECTORS.
• MALE CABLE SHELL CONNECTOR
• Section VI. MAINTENANCE OF HYDRAULIC LINES AND FITTINGS
• TUBE REDUCER TO TUBE FITTING.
• REPAIR METHODS.
• NONSKID AREAS.
• TOUCHUP AND RECOATING.
• RESTENCILING VEHICLE MARKINGS.
• MAINTENANCE OF POWERPLANT.
• Removal
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• Powerplant Inspection
• Powerplant Compartment Inspection
• Installation
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF ENGINE MOUNT.
• Installation
• MAINTENANCE OF EXTERNAL OIL LINES AND FITTINGS (UPPER ENGINE).
• Removal
• Removal (Cont)
• Removal (Cont)
• Installation
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF EXTERNAL OIL LINES AND FITTINGS (LOWER ENGINE) AND SCAVENGER RESERVOIR.
• REMOVAL
• REMOVAL (CONT)
• INSPECT/ON/REPAIR
• INSTALLATION
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• MAINTENANCE OF ENGINE OIL DIPSTICK.
• Removal
• MAINTENANCE OF OIL PAN.
• MAINTENANCE OF CRANKCASE BREATHER TUBES (ENGINE MODEL 7083-7395)
• MAINTENANCE OF FUEL PUMP.
• INSPECTION/REPAIR
• MAINTENANCE OF ENGINE FUEL LINES.
• REMOVAL
• REMOVAL (CONT)
• INSPECTION/REPAIR
• INSTALLATION
• INSTALLATION (Cont)
• MAINTENANCE OF ENGINE AIR CLEANER SYSTEM.
• REMOVAL
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• Installation
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF ENGINE INTAKE AIR DUCTS.
• REMOVAL
• MAINTENANCE OF TURBOCHARGER AIR INTAKE FILTER AND RELATED ITEMS (ENGINE MODEL 7083-7398).
• MAINTENANCE OF TURBOCHARGER AIR INTAKE SCREEN AND RELATED ITEMS (ENGINE MODEL 7083-7395).
• INSPECTION/REPAIR
• MAINTENANCE OF FUEL LINES AND FITTINGS (LOW PRESSURE) COUPLINGS TO ENGINE.
• INSPECTION/REPAIR
• INSTALLATION
• MAINTENANCE OF FUEL LINES AND FITTINGS (LOW PRESSURE) COUPLINGS TO FUEL CELLS.
• REMOVAL
• Inspection/Repair
• INSTALLATION
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• MAINTENANCE OF PRIMARY FUEL FILTER.
• REMOVAL
• INSPECTION/REPAIR
• INSTALLATION
• MAINTENANCE OF SECONDARY FUEL FILTER.
• REMOVAL
• Reassembly
• Installation
• MAINTENANCE OF FUEL AND PURGE-AND-PRIME LINES AND FITTINGS
• REMOVAL
• Installation
• MAINTENANCE OF FUEL AND PURGE-AND-PRIME LINES AND FITTINGS
• Removal
• Installation
• Installation (Cont)
• MAINTENANCE OF AIR BOX HEATER INSTALLATION AND AIR BOX HEATER ASSEMBLY
• Removal
• Removal (Cont)
• Removal (Cont)
• Disassembly
• Reassembly
• Installation
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF THROTTLE AND ACCELERATOR CONTROLS AND LINKAGE (DRIVER'S COMPARTMENT).
• Installation
• Installation (Cont)
• MAINTENANCE OF THROTTLE AND ACCELERATOR CONTROLS AND LINKAGE
• REMOVAL
• REMOVAL ( Cont)
• REMOVAL ( Cont)
• Inspection/Repair
• Installation
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Adjustment
• Adjustment (Cont)
• Adjustment (Cont)
• MAINTENANCE OF EXHAUST SYSTEM (ENGINE MODEL 7083-7398).
• REMOVAL/DISASSEMBLY
• REMOVAL/DISASSEMBLY (Cont)
• MAINTENANCE OF EXHAUST SYSTEM (ENGINE MODEL 7083-7395).
• MAINTENANCE OF RADIATOR AND RELATED PARTS.
• Removal
• Removal (Cont)
• Removal (Cont)
• Inspection/Repair
• Cleaning
• Installation
• INSTALLATION (CONT)
• INSTALLATION (CONT)
• INSTALLATION (CONT)
• MAINTENANCE OF RADIATOR SUPPORT BEAM AND RELATED PARTS.
• Removal
• Disassembly
• MAINTENANCE OF SURGE TANK AND RELATED PARTS.
• MAINTENANCE OF COOLING SYSTEM HOSES, PIPES, AND RELATED PARTS.
• Removal
• Inspection/Repair
• Inspection/Repair (Cont)
• Inspection/Repair (Cont)
• MAINTENANCE OF THERMOSTATS.
• Installation
• MAINTENANCE OF WATER BY-PASS AND CROSSOVER TUBES.
• Removal
• Installation
• MAINTENANCE OF AERATION DETECTOR.
• REMOVAL
• Installation
• Testing
• MAINTENANCE OF COOLING SYSTEM FAN TENSIONER AND RELATED PARTS.
• REMOVAL
• REMOVAL (Cont)
• REMOVAL (Cont)
• Inspection/Repair
• Reassembly
• Reassembly (Cont)
• INSTALLATION/ALIGNMENT
• INSTALLATION/ALIGNMENT (Cont)
• MAINTENANCE OF GENERATOR AND COOLING AIR INTAKE SYSTEM.
• Removal
• Inspection/Repair
• Installation
• Installation (Cont)
• MAINTENANCE OF VOLTAGE REGULATOR AND RELATED PARTS.
• Reassembly/Installation
• MAINTENANCE OF STARTER AND MOUNTING HARDWARE.
• Installation
• MAINTENANCE OF STARTER RELAY AND RELATED ITEMS.
• MAINTENANCE OF NEUTRAL POSITION SWITCH AND RELATED PARTS.
• Removal
• Installation/Adjustment
• Installation/Adjustment (Cont)
• MAINTENANCE OF DRIVER'S INSTRUMENT PANEL (SWITCH).
• Disassembly
• Inspection/Repair
• Reassembly
• REASSEMBLY (CONT)
• Installation
• Removal
• DISASSEMBLY
• DISASSEMBLY (Cont)
• INSPECTION/REPAIR
• REASSEMBLY
• REASSEMBLY (Cont)
• INSTALLATION
• MAINTENANCE OF WARNING LIGHT.
• REASSEMBLY
• DISASSEMBLY
• MAINTENANCE OF AIR BOX HEATER CONTROLS BRACKET ASSEMBLY.
• INSPECTION/REPAIR
• MAINTENANCE OF MISCELLANEOUS ELECTRICAL COMPONENTS.
• REMOVAL
• REMOVAL (CONT)
• INSPECTION/REPAIR
• INSTALLATION
• INSTALLATION (Cont)
• MAINTENANCE OF ELECTRICAL ACCESSORIES POWER BUS PANEL.
• DISASSEMBLY
• REASSEMBLY
• MAINTENANCE OF HEADLIGHT, DOME LIGHT, WARNING LIGHT, AND STOPLIGHT-TAILLIGHT INSTALLATION.
• REMOVAL
• REMOVAL (Cont)
• INSPECTION/REPAIR
• INSTALLATION
• INSTALLATION (Cont)
• ALIGNMENT CHECK
• ALIGNMENT
• MAINTENANCE OF HEADLIGHT ASSEMBLY.
• DISASSEMBLY
• DISASSEMBLY (CONT)
• DISASSEMBLY (CONT)
• DISASSEMBLY (CONT)
• REASSEMBLY
• REASSEMBLY (Cont)
• REASSEMBLY (Cont)
• REASSEMBLY (Cont)
• REASSEMBLY (Cont)
• REASSEMBLY (Cont)
• REASSEMBLY (Cont)
• REASSEMBLY (Cont)
• MAINTENANCE OF LEFT STOPLIGHT-TAILLIGHT.
• INSPECTION/REPAIR
• INSPECTION/REPAIR (Cont)
• MAINTENANCE OF RIGHT STOPLIGHT-TAILLIGHT.
• INSPECTION/REPAIR
• REASSEMBLY
• MAINTENANCE OF DRIVER'S COMPARTMENT DOME LIGHT.
• DISASSEMBLY
• DISASSEMBLY (CONT)
• INSPECTION/REPAIR
• REASSEMBLY
• REASSEMBLY (CONT)
• MAINTENANCE OF SENDING UNITS, WARNING SWITCHES, AND INDICATOR LIGHTS
• REMOVAL
• REMOVAL (Cont)
• lNSPECTION/REPAIR
• INSTALLATION
• INSTALLATION (CONT)
• INSTALLATION (CONT)
• INSTALLATION (CONT)
• Adjustment
• Disassembly
• INSPECTION/REPAIR
• MAINTENANCE OF AUDIBLE WARNING HORN AND RELATED PARTS.
• REMOVAL
• INSTALLATION
• MAINTENANCE OF BATTERIES, ELECTRICAL LEADS, AND RELATED PARTS.
• REMOVAL
• Installation
• Installation (Cont)
• MAINTENANCE OF BULKHEAD DISCONNECT TO SWITCH PANEL BRANCHED WIRING HARNESS.
• INSPECTION/REPAIR
• Installation
• MAINTENANCE OF BULKHEAD DISCONNECT TO ENGINE COMPONENTS AND WARNING UNITS BRANCHED WIRING HARNESS.
• REMOVAL
• DISASSEMBLY
• Installation
• Installation (Cont)
• MAINTENANCE OF BULKHEAD DISCONNECT TO DRIVER'S CONTROL BRANCHED WIRING HARNESS.
• Removal
• Removal (Cont)
• INSPECTION/REPAIR
• Installation
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF SUSPENSION LOCKOUT SYSTEM WARNING LIGHT GROUND AND HORN GROUND ELECTRICAL LEADS.
• Removal
• INSPECTION/REPAIR
• DISASSEMBLY
• INSPECTION/REPAIR
• REMOVAL
• INSPECTION/REPAIR
• MAINTENANCE OF BATTERY TO CIRCUIT BREAKER ELECTRICAL LEAD.
• INSTALLATION
• MAINTENANCE OF BULKHEAD DISCONNECT TO GENERATOR ARMATURE ELECTRICAL LEAD.
• INSPECTION/REPAIR
• MAINTENANCE OF BULKHEAD DISCONNECT TO STARTER ELECTRICAL LEAD.
• INSPECTION/REPAIR
• MAINTENANCE OF BULKHEAD TO BULKHEAD GENERATOR CIRCUIT ELECTRICAL LEAD.
• Installation
• MAINTENANCE OF BULKHEAD DISCONNECT TO VOLTAGE REGULATOR ASSEMBLY WIRING HARNESS.
• INSPECTION/REPAIR
• Installation
• MAINTENANCE OF FLOOR DISCONNECT TO BULKHEAD DISCONNECT WIRING HARNESS
• REMOVAL
• Installation
• MAINTENANCE OF BULKHEAD DISCONNECT TO MAGNETIC CLUTCH BRANCHED WIRING HARNESS.
• Installation
• MAINTENANCE OF BULKHEAD DISCONNECT TO CIRCUIT BREAKER BRANCHED WIRING HARNESS.
• Removal
• Installation
• Installation (Cont)
• MAINTENANCE OF HULL DISCONNECT TO SLIP RING LEAD AND CIRCUIT BREAKER
• Disassembly
• REASSEMBLY
• Installation
• MAINTENANCE OF BLOWER TO GROUND ELECTRICAL LEAD.
• INSTALLATION
• MAINTENANCE OF INTERCOM CIRCUIT BULKHEAD DISCONNECT TO SLIP RING BRANCHED WIRING HARNESS.
• Inspection/Repair
• Installation
• MAINTENANCE OF HORN TO WARNING RELAY WIRING HARNESS.
• REMOVAL
• Installation
• MAINTENANCE OF GENERATOR CONTROL CIRCUITS TO BRACKET DISCONNECT BRANCHED WIRING HARNESS.
• REMOVAL
• MAINTENANCE OF DISCONNECT TO INSTRUMENT PANEL BRANCHED WIRING HARNESS.
• Removal
• Installation
• MAINTENANCE OF DISCONNECT TO FORWARD AIR CLEANER BLOWER MOTOR ELECTRICAL LEAD.
• Inspection/Repair
• MAINTENANCE OF FUEL PURGE-AND-PRIME SWITCH TO SOLENOID ELECTRICAL LEAD (ENGINE MODEL 7083-7395).
• Removal
• MAINTENANCE OF BULKHEAD DISCONNECT TO TRAILER RECEPTACLE DISCONNECT, AFT BLOWER MOTOR, AND TAILLIGHTS BRANCHED WIRING HARNESS
• Removal
• INSPECTION/REPAIR
• Installation
• MAINTENANCE OF LIGHTING SWITCH TO VEHICLE ACCESSORIES AND DISCONNECT BRANCHED WIRING HARNESS.
• Removal
• Inspection/Repair
• Installation
• MAINTENANCE OF BATTERY TO BULKHEAD DISCONNECT CABLE ASSEMBLY
• REMOVAL
• INSTALLATION
• MAINTENANCE OF BULKHEAD TO BULKHEAD STARTER CIRCUIT BRANCHED WIRING HARNESS.
• Installation
• MAINTENANCE OF RIGHT AND LEFT DISCONNECT TO HEADLAMP WIRING HARNESS
• DISASSEMBLY
• REASSEMBLY
• Installation
• MAINTENANCE OF RELAY TO STARTER AND NEUTRAL POSITION SWITCH BRANCHED WIRING HARNESS.
• Removal
• MAINTENANCE OF FUEL PURGE-AND-PRIME SWITCH TO SOLENOID ELECTRICAL LEAD (ENGINE MODEL 7083-7398).
• MAINTENANCE OF WARNING LIGHT LOW COOLANT DETECTOR TO BULKHEAD DISCONNECT BRANCHED WIRING HARNESS.
• Removal
• Installation
• MAINTENANCE OF AERATION DETECTOR BRANCHED WIRING HARNESS.
• MAINTENANCE OF LOW COOLANT WARNING LIGHT TO BULKHEAD DISCONNECT BRANCHED WIRING HARNESS.
• Removal
• MAINTENANCE OF MASTER RELAY TO BULKHEAD DISCONNECT SPECIAL CABLE ASSEMBLY.
• Removal
• MAINTENANCE OF VOLTAGE REGULATOR TO BULKHEAD DISCONNECT, SLAVE RECEPTACLE, AND ACCESSORIES PANEL SPECIAL CABLE ASSEMBLY; AND SLAVE RECEPTACLE AND GROUND ELECTRICAL LEAD.
• Removal
• Inspection/Repair
• Installation
• MAINTENANCE OF AIR CLEANER BLOWER RELAY TO BULKHEAD DISCONNECT BRANCHED WIRING HARNESS.
• Removal
• Installation
• MAINTENANCE OF NEUTRAL POSITION SAFETY SWITCH TO ENGINE DISCONNECT ELECTRICAL LEAD.
• Removal
• MAINTENANCE OF GENERATOR TO GROUND ENGINE IGNITION LEAD.
• Removal
• MAINTENANCE OF STARTER TO GROUND ELECTRICAL LEAD.
• Ramoval
• MAINTENANCE OF TRANSMISSION COMPONENTS.
• MAINTENANCE OF TRANSMISSION AND TRANSMISSION PLUGS.
• Removal
• Inspection/Repair
• Test
• Test (Cont)
• Test (Cont)
• Test (Cont)
• Figure 2-1. Transmission Pressure Test Points.
• Figure 2-2. Transmission Pressure Test Readings .
• MAINTENANCE OF OIL SAMPLING DRAIN COCK AND RELATED ITEMS.
• Removal
• Installation
• MAINTENANCE OF FINAL DRIVE ASSEMBLY.
• Removal/Disassembly
• Inspection/Repair
• Reassembly/Installation
• Reassembly/Installation (Cont)
• MAINTENANCE OF AUXILIARY DRIVE INSTALLATION.
• Inspection/Repair
• Inspection/Repair (Cont)
• MAINTENANCE OF AUXILIARY DRIVE ASSEMBLY (VEHICULAR DRIVE).
• DISASSEMBLY
• MAINTENANCE OF OIL FILLER NECK.
• Reassembly/Installation
• MAINTENANCE OF OIL DRAIN TUBE ASSEMBLY.
• REMOVAL/DISASSEMBLY
• MAINTENANCE OF SHIFTING CONTROL AND LINKAGE.
• REMOVAL/DISASSEMBLY
• INSPECTION/REPAIR
• REASSEMBLY/lNSTALLATION
• REASSEMBLY/lNSTALLATION (Cont)
• ADJUSTMENT
• MAINTENANCE OF IMPACT WRENCH CONTROL HYDRAULIC LINES AND FITTINGS AND IMPACT WRENCH REGULATOR BALL VALVE.
• REMOVAL/DISASSEMBLY
• REMOVAL/DISASSEMBLY (Cont)
• REMOVAL/DISASSEMBLY (Cont)
• REMOVAL/DISASSEMBLY (Cont)
• REASSEMBLY/lNSTALLATION
• REASSEMBLY/lNSTALLATION (Cont)
• REASSEMBLY/lNSTALLATION (Cont)
• REASSEMBLY/lNSTALLATION (Cont)
• MAINTENANCE OF HYDRAULIC POWER SUPPLY LINES AND FITTINGS (FORWARD SECTION).
• REMOVAL
• REMOVAL (CONT)
• REMOVAL (CONT)
• lNSTALLATION
• lNSTALLATION (Cont)
• lNSTALLATION (Cont)
• MAINTENANCE OF HYDRAULIC POWER SUPPLY LINES AND FITTINGS (AFT SECTION).
• REMOVAL
• REMOVAL (Cont)
• REMOVAL (Cont)
• INSTALLATION
• INSTALLATION (CONT)
• MAINTENANCE OF FLUID FILTER.
• Disassembly
• INSPECTION/REPAIR
• MAINTENANCE OF AUXILIARY DRIVE SHAFTS, UNIVERSAL JOINTS, AND RELATED PARTS.
• REMOVAL
• REMOVAL (Cont)
• INSPECTION/REPAIR
• Reassembly
• INSTALLATION
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• MAINTENANCE OF PARKING BRAKE CONTROL AND LINKAGE.
• INSPECTION/REPAIR
• MAINTENANCE OF PARKING BRAKE ASSEMBLY.
• DISASSEMBLY
• INSPECTION/REPAIR
• Reassembly
• ADJUSTMENT
• Removal
• Installation
• Installation (Cont)
• Adjustment
• Adjustment (Cont)
• Adjustment (Cont)
• MAINTENANCE OF TORSION BARS.
• Removal
• Removal (Cont)
• Removal (Cont)
• Removal (Cont)
• Installation
• Installation (Cont)
• MAINTENANCE OF TORSION BAR SOCKETS.
• Installation
• MAINTENANCE OF ROADWHEEL ARM AND HUB ASSEMBLY AND ATTACHING PARTS; AND ROADWHEEL PIVOT ARM ASSEMBLY.
• Removal/Disassembly
• REMOVAL/DISASSEMBLY (CONT)
• Reassembly/Installation
• REASSEMBLY/lNSTALLATION (CONT)
• REASSEMBLY/lNSTALLATION (CONT)
• MAINTENANCE OF ROADWHEEL SUSPENSION HUB AND HUB CAP RADIO STATIC SUPPRESSION SPRING.
• Disassembly
• DISASSEMBLY (CONT)
• Reassembly
• Reassembly (cont)
• Installation/Adjustment
• MAINTENANCE OF IDLER WHEEL, ROADWHEEL WHEEL, AND LEFT LUBRICATION TUBE.
• Removal
• Removal (Cont)
• Removal (Cont)
• Installation
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF IDLER WHEEL ARM AND HUB ASSEMBLY AND ATTACHING PARTS, AND IDLER WHEEL ARM AND HUB.
• Removal/Disassembly
• Removal/Disassembly (Cont)
• Removal/Disassembly (Cont)
• Removal/Disassembly (Cont)
• Reassembly/Installation
• Reassembly/Installation (Cont)
• Reassembly/Installation (Cont)
• Reassembly/Installation (Cont)
• MAINTENANCE OF IDLER WHEEL VEHICULAR WHEEL HUB AND HUB CAP RADIO STATIC SUPPRESSION SPRING.
• Removal
• Installation
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF DRIVE HUB SPROCKETS AND RELATED PARTS.
• Inspection/Rapair
• Installation
• Installation (Cont)
• MAINTENANCE OF VEHICULAR TRACK SHOE INSTALLATION AND VEHICULAR TRACK SHOE.
• Removal
• Inspection/Repair
• Reassembly
• Installation/Adjustment
• MAINTENANCE OF STEERING CONTROLS AND LINKAGE AND STEERING ROD ASSEMBLY.
• Reassembly/Installation
• Adjustment
• Removal
• MAINTENANCE OF TOW HOOK AND RELATED PARTS.
• MAINTENANCE OF LOCKOUT CYLINDER AND RELATED PARTS.
• Removal
• Installation
• Installation (Cont)
• MAINTENANCE OF SUSPENSION LOCKOUT SYSTEM CONTROL VALVE AND ASSOCIATED PARTS.
• REMOVAL
• REMOVAL (cont)
• REMOVAL (cont)
• Installation
• INSTALLATION (CONT)
• INSTALLATION (CONT)
• MAINTENANCE OF SUSPENSION SYSTEM HYDRAULIC LINES AND FITTINGS (RIGHT SIDE) AND ATTACHING HARDWARE.
• Removal
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• REMOVAL (CONT)
• Installation
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF SUSPENSION SYSTEM HYDRAULIC LINES AND FITTINGS (LEFT SIDE) AND ATTACHING HARDWARE.
• Removal/Disassembly
• Removal/Disassembly (cont)
• Removal/Disassembly (cont)
• Removal/Disassembly (cont)
• Removal/Disassembly (cont)
• Removal/Disassembly (cont)
• Reassembly/Installation
• Reassembly/Installation (Cont)
• Reassembly/Installation (Cont)
• Reassembly/Installation (Cont)
• Reassembly/Installation (Cont)
• Reassembly/Installation (Cont)
• MAINTENANCE OF HULL COVERS AND ACCESS DOORS.
• Removal/Disassembly
• Inspection/Repair
• Reassembly/Installation
• REASSEMBLY/lNSTALLATION (CONT)
• MAINTENANCE OF HULL COVERS, DOORS, AND PLATES .
• REMOVAL
• INSPECTION/REPAIR
• INSTALLAT/ON
• INSTALLATION (Cont)
• MAINTENANCE OF HULL DECK AND MISCELLANEOUS COMPONENTS.
• REMOVAL
• REMOVAL (CONT)
• Inspection/Repair
• Installation
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF HULL ENGINE COMPARTMENT DECK ASSEMBLY LID.
• Disassembly
• REASSEMBLY
• MAINTENANCE OF HULL TRANSMISSION COMPARTMENT DECK ASSEMBLY.
• Disassembly
• INSPECTION/REPAIR
• Reassembly
• MAINTENANCE OF MUD GUARDS, FENDER EXTENSIONS, AND ATTACHING PARTS
• Installation
• REAMOVAL/DISASSEMBLY
• INSPECTION/REPAIR
• REASSEMBLY/INSTALLATION
• MAINTENANCE OF HULL DRAIN PLUGS, VALVES, AND RELATED PARTS.
• Removal
• Removal (Cont)
• Installation
• Installation (cont)
• MAINTENANCE OF DRIVER'S SEAT AND ASSOCIATED PARTS.
• REMOVAL
• REMOVAL (Cont)
• Installation
• Installation (Cont)
• MAINTENANCE OF VEHICULAR SEAT.
• REASSEMBLY
• MAINTENANCE OF HULL STOWAGE CLAMPS, RETAINERS, AND ASSOCIATED PARTS.
• REMOVAL
• REMOVAL (Cont)
• REMOVAL (Cont)
• Installation
• INSTALLATION (CONT)
• INSTALLATION (CONT)
• INSTALLATION (CONT)
• MAINTENANCE OF SPADE AND RELATED PARTS.
• REMOVAL
• REMOVAL (Cont)
• REMOVAL (Cont)
• REMOVAL (Cont)
• REMOVAL (Cont)
• Inspection/Repair
• Testing
• Testing (cont)
• INSTALLATION
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• MAINTENANCE OF SPADE HYDRAULIC CONTROL VALVES, LINES, AND FITTINGS
• Removal
• Removal (Cont)
• Removal (Cont)
• Removal (Cont)
• Removal (Cont)
• Inspection/Repair
• INSTALLATION
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• MAINTENANCE OF VEHICLE DATA PLATES.
• Removal
• Removal (Cont)
• Removal (Cont)
• Installation
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF HEATER INSTALLATION KIT.
• Removal
• Removal (Cont)
• Installation
• Installation (Cont)
• Removal
• Removal (Cont)
• Installation
• Installation (COnt)
• MAINTENANCE OF HEATER INSTALLATION KIT--BATTERY BOX AND COVERS
• Installation
• MAINTENANCE OF HEATER INSTALLATION KIT--HOSES AND FITTINGS.
• Removal
• INSPECTION/REPAIR
• INSTALLATION
• INSTALLATION (Cont)
• MAINTENANCE OF HEATER INSTALLATION KIT--FUEL LINES AND FITTINGS.
• Removal
• Removal (Cont)
• Inspection/Repair
• Installation
• Installation (Cont)
• MAINTENANCE OF HEATER INSTALLATION KIT--DRIVER'S HEATER AIR HOSES
• Inspection/Repair
• Installation
• MAINTENANCE OF HEATER INSTALLATION KIT--AIR INTAKE BLOWER, FUEL FILTER HEATERS, AND CONNECTING HARNESS; AND POWER PLANT COMPARTMENT BRANCHED WIRING HARNESS.
• REMOVAL
• Installation
• Installation (Cont)
• MAINTENANCE OF HEATER INSTALLATION KIT--ELECTRICAL COMPONENTS
• REMOVAL
• REMOVAL (Cont)
• REMOVAL (Cont)
• Installation
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF HEATER INSTALLATION KIT--AIR INTAKE COVERS, PLATES, AND RELATED ITEMS.
• Inspection/Repair
• Installation
• Installation (Cont)
• MAINTENANCE OF HEATER INSTALLATION KIT--ELECTRICAL WIRING.
• Removal of Battery Positive Terminal to Circuit Breaker Electrical Leads
• Removal of Bulkheads Disconnect to Circuit Breakers and Electrical Components Branched Wiring Harness
• Removal of Bulkheads Disconnect to Circuit Breakers and Electrical Components Branched Wiring Harness (Cont)
• Removal of Bulkhead Disconnect to Master Relay and Circuit Breaker Special Cable Assembly
• Removal of Heater Control Box Driver's Heater Wiring Harness
• Installation of Heater Control Box to Driver's Heater Wiring Harness
• Installation of Bulkhead Disconnects to Master Relay and Circuit Breaker Special Cable Assembly
• Installation of Bulkhead Disconnect to Circuit Breakers and Electrical Components Branched Wriring Harness
• Installation of Coolant Heater Circuit Breaker to Line Discconect Special Cable Assembly
• Installation of Battery Positive Terminal to Circuit Breaker Electrical Leads
• Maintenance of Filter Mounting Fluid Filter (Heater Installation Kit)
• Reassembly
• Disassembly
• Reassembly
• MAINTENANCE OF HEATER ELECTRICAL CONTROL BOX (HEATER INSTALLATION KIT)
• MAINTENANCE OF ENGINE COOLANT HEATER AND COOLANT HEATER ASSEMBLY BRANCHED WIRING HARNESS (HEATER INSTALLATION KIT).
• Disassembly
• Disassembly (Cont)
• Disassembly (Cont)
• Disassembly (Cont)
• Inspection/Repair
• REASSEMBLY
• REASSEMBLY (Cont)
• REASSEMBLY
• REASSEMBLY (Cont)
• REASSEMBLY (Cont)
• Installation
• MAINTENANCE OF VEHICULAR HEATER (DRIVER'S COMPARTMENT) (HEATER INSTALLATION KIT).
• Installation
• MAINTENANCE OF DRIVER'S WINDSHIELD ENCLOSURE KIT--ELECTRICAL WIRING
• Removal
• Installation
• MAINTENANCE OF DRIVER'S WINDSHIELD ENCLOSURE KIT--DRIVER'S BASE ASSEMBLY AND RELATED PARTS AND ENCLOSURE.
• REMOVAL
• REMOVAL (Cont)
• REMOVAL (Cont)
• INSPECTION/REPAIR
• INSTALLATION
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• MAINTENANCE OF DRIVER'S AND CRANE OPERATOR'S VEHICULAR WINDOWS (DRIVER'S WINDSHIELD ENCLOSURE KIT).
• DISASSEMBLY
• REASSEMBLY
• REASSEMBLY (Cont)
• DISASSEMBLY
• DISASSEMBLY (Cont)
• REASSEMBLY
• REASSEMBLY (Cont)
• REMOVAL
• REMOVAL (Cont)
• INSTALLATION
• INSTALLATION (Cont)
• MAINTENANCE OF VEHICULAR PARTS KIT--BOOTS, PLUGS, TRAYS, AND RELATED PARTS.
• REMOVAL
• INSPECTIONIREPAIR
• INSTALLATION
• INSTALLATION (Cont)
• MAINTENANCE OF VEHICULAR PARTS KIT (HEATER AND RELATED PARTS) AND CIRCUIT BREAKER TO HEATER CONTROL BOX BRANCHED WIRING HARNESS.
• REMOVAL
• REMOVAL (Cont)
• Installation
• Installation (Cont)
• MAINTENANCE OF PERSONNEL VEHICULAR HEATER ASSEMBLY, PERSON- NEL VEHICULAR HEATER ASSEMBLY (TANK ASSEMBLY, FILTER, AND PUMP), AND CONTROL BOX ASSEMBLY TO HEATER ASSEMBLY WIRING HARNESS (WINTERIZATION KIT).
• DISASSEMBLY
• DISASSEMBLY (cont)
• DISASSEMBLY (CONT)
• INSPECTION/REPAIR
• REASSEMBLY (CONT)
• REASSEMBLY (CONT) - continued
• REASSEMBLY (CONT) - continued
• MAINTENANCE OF CRANE OPERATOR'S ENCLOSURE KIT.
• INSTALLATION
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• REMOVAL
• REMOVAL (Cont)
• REMOVAL (Cont)
• REMOVAL (Cont)
• REMOVAL (Cont)
• MAINTENANCE OF CRANE OPERATOR'S ENCLOSURE KIT--ELECTRICAL WIRING
• INSPECTION/REPAIR
• Installation
• MAINTENANCE OF CRANE OPERATOR'S ENCLOSURE KIT--ENCLOSURE.
• Removal
• Removal (Cont)
• Removal (Cont)
• INSPECTION/REPAIR
• INSTALLATION
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• MAINTENANCE OF CRANE WINDOW ASSEMBLY.
• DISASSEMBLY
• INSPECTION/REPAIR
• Reassembly
• MAINTENANCE OF CRANE OPERATOR'S BASE ASSEMBLY.
• DISASSEMBLY
• REASSEMBLY
• MAINTENANCE OF ARCTIC TRACTION KIT.
• Removal
• INSPECTION/REPAIR
• REASSEMBLY
• MAINTENANCE OF SPEEDOMETER, TACHOMETER, AND RELATED PARTS.
• REMOVAL
• REMOVAL (Cont)
• INSTALLATION
• INSTALLATION (Cont)
• INSTALLATION (Cont)
• MAINTENANCE OF FIXED FIRE EXTINGUISHER CONTROL SYSTEM.
• REMOVAL
• REMOVAL (Cont)
• REMOVAL (Cont)
• REMOVAL (Cont)
• Installation
• Installation (Cont)
• Installation (Cont)
• Installation (Cont)
• MAINTENANCE OF FIXED FIRE EXTINGUISHER CONNECTING LINES AND FITTINGS
• REMOVAL
• REMOVAL (CONT)
• lNSPECTION/REPAIR
• INSTALLATION
• MAINTENANCE OF FIXED FIRE EXTINGUISHER FORWARD NOZZLE, LINES AND FITTINGS.
• Removal
• Installation
• MAINTENANCE OF FIXED FIRE EXTINGUISHER REAR NOZZLE, LINES AND FITTINGS
• Removal
• MAINTENANCE OF FIRE EXTINGUISHER RETAINING STRAP.
• MAINTENANCE OF CYLINDER FIRE EXTINGUISHER.
• MAINTENANCE OF 12 C.F.M. FOUR-MAN TANK GAS-PARTICULATE FILTER UNIT M8A3.
• Removal
• Installation
• Installation (Cont)
• Section VIII. PREPARATION FOR STORAGE OR SHIPMENT
• Storage Plan.
• CARE OF EQUIPMENT IN ADMINISTRATIVE STORAGE.
• CARE OF EQUIPMENT IN ADMINISTRATIVE STORAGE. (Cont)
• Appendix A: REFERENCES
• Appendix A: REFERENCES (Cont)
• Appendix A: REFERENCES (Cont)
• Appendix B: MAINTENANCE ALLOCATION CHART
• MAINTENANCE FUNCTIONS
• EXPLANATION OF COLUMNS IN THE MAC, SECTION Il.
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Il. MAINTENANCE ALLOCATION CHART FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6242) HULL AND RELATED COMPONENTS (Continued)
• Section Ill. TOOL AND TEST EQUIPMENT REQUIREMENTS FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6262) HULL AND RELATED COMPONENTS
• Section Ill. TOOL AND TEST EQUIPMENT REQUIREMENTS FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6262) HULL AND RELATED COMPONENTS (CONT)
• Section Ill. TOOL AND TEST EQUIPMENT REQUIREMENTS FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6262) HULL AND RELATED COMPONENTS (CONT)
• Section Ill. TOOL AND TEST EQUIPMENT REQUIREMENTS FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6262) HULL AND RELATED COMPONENTS (CONT)
• Section Ill. TOOL AND TEST EQUIPMENT REQUIREMENTS FOR RECOVERY VEHICLE, FULL TRACKED: LIGHT ARMORED, M578 (2350-00-439-6262) HULL AND RELATED COMPONENTS (CONT)
• Section IV. REMARKS
• Appendix C: EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST
• Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST
• Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST (Cont)
• Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST (Cont)
• Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST (Cont)
• Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST (Cont)
• Appendix D: ILLUSTRATED LIST OF MANUFACTURED ITEMS
• MANUFACTURED ITEMS PART NUMBER INDEX
• Figure D-2. Electrical Wire.
• Figure D-3. Electrical Cable.
• Figure D-4. Hose.
• Figure D-6. Heater Mount Chain.
• Figure D-9. Nylon Cord.
• Figure D-11. Nonmetallic Channel.
• Figure D-14. Seal.
• Figure D-17. Rubber Hose.
• Figure D-19. Insulation Sleeving.
• Figure D-22. Insulation Sleeving.
• Figure D-24. Nonmetallic Rod or Rod.
• Figure D-26. Air Duct Hose.
• Appendix E: TORQUE VALUES
• TORQUE VALUE GUIDE
• Appendix F: HYDRAULIC SYSTEM DESCRIPTION AND SCHEMATIC DIAGRAMS
• HYDRAULIC SYMBOLS.
• HYDRAULIC SYMBOLS. (Cont)
• HYDRAULIC POWER SUBSYSTEM
• HYDRAULIC POWER SUBSYSTEM (Cont)
• HYDRAULIC POWER SUBSYSTEM (Cont)
• HYDRAULIC POWER SUBSYSTEM (Cont)
• HYDRAULIC POWER SUBSYSTEMHAND PUMP OPERATING.
• HYDRAULIC POWER SUBSYSTEMHAND PUMP OPERATING. (Cont)
• BOOM WINCH HYDRAULIC SUBSYSTEM.
• BOOM WINCH HYDRAULIC SUBSYSTEM. (Cont)
• BOOM WINCH HYDRAULIC SUBSYSTEMPAY IN.
• BOOM WINCH HYDRAULIC SUBSYSTEMPAY IN. (Cont)
• BOOM WINCH HYDRAULIC SUBSYSTEMPAY - PAY OUT
• BOOM WINCH HYDRAULIC SUBSYSTEMPAY - PAY OUT (Cont)
• BOOM WINCH HYDRAULIC SUBSYSTEM MANUAL RELEASE.
• BOOM WINCH HYDRAULIC SUBSYSTEM MANUAL RELEASE. (Cont)
• TRAVERSING HYDRAULIC SUBSYSTEM.
• TRAVERSING HYDRAULIC SUBSYSTEM. (Cont)
• TRAVERSING HYDRAULIC SUBSYSTEM TRAVERSING LEFT.
• TRAVERSING HYDRAULIC SUBSYSTEM TRAVERSING LEFT. (Cont)
• TRAVERSING HYDRAULIC SUBSYSTEM TRAVERSING LEFT. (Cont)
• TRAVERSING HYDRAULIC SUBSYSTEM TRAVERSING LEFT. (Cont)
• TRAVERSING HYDRAULIC SUBSYSTEMLEVEL WIND TRAVERSING RIGHT.
• TRAVERSING HYDRAULIC SUBSYSTEMLEVEL WIND TRAVERSING RIGHT. (Cont)
• TRAVERSING HYDRAULIC SUBSYSTEMLEVEL WIND TRAVERSING LEFT.
• TRAVERSING HYDRAULIC SUBSYSTEMLEVEL WIND TRAVERSING LEFT. (Cont)
• TRAVERSING HYDRAULIC SUBSYSTEM MANUAL RELEASE.
• TRAVERSING HYDRAULIC SUBSYSTEM MANUAL RELEASE. (Cont)
• BOOM CYLINDER HYDRAULIC SUBSYSTEM.
• BOOM CYLINDER HYDRAULIC SUBSYSTEM. (Cont)
• BOOM CYLINDER HYDRAULIC SUBSYSTEMLOWERING BOOM.
• BOOM CYLINDER HYDRAULIC SUBSYSTEMLOWERING BOOM. (Cont)
• BOOM CYLINDER HYDRAULIC SUBSYSTEMRAISING BOOM.
• BOOM CYLINDER HYDRAULIC SUBSYSTEMRAISING BOOM. (Cont)
• BOOM CYLINDER HYDRAULIC SUBSYSTEMMANUAL LOWERING.
• BOOM CYLINDER HYDRAULIC SUBSYSTEMMANUAL LOWERING. (Cont)
• TOW WINCH HYDRAULIC SUBSYSTEM.
• TOW WINCH HYDRAULIC SUBSYSTEM. (Cont)
• TOW WINCH HYDRAULIC SUBSYSTEMPAYING IN.
• TOW WINCH HYDRAULIC SUBSYSTEMPAYING IN. (Cont)
• TOW WINCH HYDRAULIC SUBSYSTEMPAYING OUT.
• TOW WINCH HYDRAULIC SUBSYSTEMPAYING OUT. (Cont)
• IMPACT WRENCH HYDRAULIC SUBSYSTEM.
• IMPACT WRENCH HYDRAULIC SUBSYSTEMDRIVING RIGHT.
• IMPACT WRENCH HYDRAULIC SUBSYSTEMDRIVING LEFT.
• SPADE HYDRAULIC SUBSYSTEM.
• SPADE HYDRAULIC SUBSYSTEMRETRACTING SPADE CYLINDERS.
• SPADE HYDRAULIC SUBSYSTEMRETRACTING SPADE CYLINDERS. (Cont)
• SPADE HYDRAULIC SUBSYSTEMEXTENDING SPADE CYLINDERS.
• SPADE HYDRAULIC SUBSYSTEMEXTENDING SPADE CYLINDERS. (Cont)
• SUSPENSION LOCKOUT HYDRAULIC SUBSYSTEM.
• SUSPENSION LOCKOUT HYDRAULIC SUBSYSTEM. (Cont)
• SUSPENSION LOCKOUT HYDRAULIC SUBSYSTEM CYLINDERS LOCKED.
• SUSPENSION LOCKOUT HYDRAULIC SUBSYSTEM CYLINDERS LOCKED. (Cont)
• SUSPENSION LOCKOUT HYDRAULIC SUBSYSTEMCYLINDERS UNLOCKED.
• SUSPENSION LOCKOUT HYDRAULIC SUBSYSTEMCYLINDERS UNLOCKED. (Cont)
• Appendix G: SPECIAL TOOLS AND EQUIPMENT
• SPECIAL TOOLS AND EQUIPMENT (Cont)
• SPECIAL TOOLS AND EQUIPMENT (Cont)
• SPECIAL TOOLS AND EQUIPMENT (Cont)
• SPECIAL TOOLS AND EQUIPMENT (Cont)
• SPECIAL TOOLS AND EQUIPMENT (Cont)
• SPECIAL TOOLS AND EQUIPMENT (Cont)
• SPECIAL TOOLS AND EQUIPMENT (Cont)
• SPECIAL TOOLS AND EQUIPMENT (Cont)
• SPECIAL TOOLS AND EQUIPMENT (Cont)
• ALPHABETICAL INDEX
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• ALPHABETICAL INDEX (Continued)
• FO-1. Vehicle electrical system schematic diagram (sheet 1 of 2)
• FO-1. Vehicle electrical system schematic diagram (sheet 2 of 2)
• The Metric System and Equivalents
• TM-9-2350-238-20-1
• Blank Page
• Recommended Changes to Equipment Technical Publications
• Recommended Changes to Equipment Technical Publications
• By Order of the Secretary of the Army:
• Recommended Changes to Equipment Technical Publications

Privacy Statement - Press Release - Copyright Information. - Contact Us