TM-5-6640-214-14

• OPERATOR'S ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
• OPERATOR'S ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
• WARNING
• WARNING
• WARNING
• WARNING
• TABLE OF CONTENTS
• LIST OF ILLUSTRATIONS
• LIST OF ILLUSTRATIONS (Continued)
• CHAPTER 1 INTRODUCTION
• HAND RECEIPT
• DESTRUCTION OF ARMY MATERIEL TO PREVENT ENEMY USE
• REPORTING EQUIPMENT IMPROVEMENT RECOMMENDATIONS (EIR)
• Figure 1-1. Unit of Cabinets Assembled Along Left Wall, Forward Portion
• Figure 1-2. Unit of Cabinets Assembled Along Left Wall, Rear Portion
• Figure 1-3. Unit of Cabinets Assembled Along End Wall
• Figure 1-4. Unit of Cabinets Assembled Along Right Wall, Rear Portion
• Figure 1-5. Unit of Cabinets Assembled Along Right Wall, Forward Portion
• CABINET UNITS
• TABULATED DATA
• TABULATED DATA
• CHAPTER 2 OPERATING INSTRUCTIONS
• Figure 2-1. Shipping Container and Platform (81337) 5-14-341
• Figure 2-2. Shipping Container, Closed and Locked (81337) 5-14-341
• Section II. SETTING-UP PROCEDURES
• CONNECTING SERVICE LINES
• Figure 2-4. Proposed Layout for Petroleum Base Laboratory in Baker Building
• Figure 2-5. Flexible Metal Braided Hose Used to Connect Service Lines Around a Corner
• CONNECTING SERVICE LINES. cont'd
• Figure 2-6. Wiring Diagram for Unit of Six Cabinets
• Figure 2-7. Wiring Diagram for Low Temperature Kinematic Viscosimeter.
• Figure 2-8. Wiring Diagram for Cloud- and Pour-Point Apparatus.
• Figure 2-9. Wiring Diagram for Channel Point Apparatus.
• Section III. OPERATION AND MAINTENANCE
• Safety Precautions
• Safety Precautions cont'd
• Handling Chemicals
• Controlling Pressure and Vacuum
• Controlling Fumes
• Electrical Safety
• Figure 2-10. Water Bath and Electric Oven Cabinet.(Unit No. 1)
• Figure 2-11. Collapsible Laboratory Stool.
• HIGH TEMPERATURE KINEMATIC VISCOSIMETER CABINET
• Figure 2-12. High Temperature Kinematic Vicosimeter Cabinet. (Unit No. 2)
• DISTILLATION CABINETS
• Figure 2-13. Distillation Cabinet (Double) (Unit No. 3)
• Figure 2-14. Distillation Cabinet (Single) (Unit No. 4)
• MUFFLE FURNACE AND PENETROMETER CABINET
• Muffle furnace
• GUM APPARATUS CABINET
• Figure 2-16. Gum Apparatus Cabinet. (Unit No. 6)
• WATER STILL CABINET
• Figure 2-17. Water Still Cabinet (Unit No. 7)
• TETRAETHYL LEAD AND SULFUR DETERMINATIOUN APPARATUS CABINET
• Figure 2-18. Tetraethyl Lead and Sulfur Determination Apparatus Cabinet (Unit No. 8)
• Figure 2-18.1. Glassware Storage Cabinet (Units No. 9 thru 14, 24 and 26)
• Figure 2-18.2. Chemical Storage Cabinet (Unit No. 15)
• STORAGE CABINETS
• Figure 2-19. Balance Cabinet (Unit No. 16)
• BOOKCASE
• Figure 2-20. Sink Cabinet, with Equipment Prepared for Shipment or Storage (Unit No. 17)
• Figure 2-21. Oxidation Stability Cabinet (Unit No. 18)
• FUME HOODS
• Figure 2-22. Fume Hood (Unit No. 19)
• LOW TEMPERATURE KINEMATIC VISCOSIMETER CABINET
• Figure 2-23. Low Temperature Kinematic Viscosimeter Cabinet (Unit No. 20)
• Figure 2-24. Refrigerator Cabinet (Unit No. 21)
• Figure 2-25. Cloud- and Pour-Point Apparatus Cabinet (Unit No. 22)
• AIR COMPRESSOR
• Figure 2-26. Air Compressor (Unit No. 23)
• CENTRIFUGE AND CHANNEL POINT APPARATUS CABINET
• Figure 2-27. Centrifuge and Channel Point Apparatus Cabinet (Unit No. 25)
• CONSTANT TEMPERATURE BATH, REID VAPOR PRESSURE (RVP)
• GAS CYLINDERS
• GAS CYLINDERS cont'd
• ANEROID BAROMETER
• MANOMETER
• Figure 2-28. Analytical Balance
• Figure 2-29. Analytical Balance, Side View
• Figure 2-30. Top View of Analytical Balance
• Scale focusing
• CHAPTER 3 OPERATOR/CREW MAINTENANCE INSTRUCTIONS
• Table 3-1. Preventive Maintenance Checks and Services
• Table 3-1. Preventive Maintenance Checks and Services
• Table 3-1. Preventive Maintenance Checks and Services
• Table 3-1. Preventive Maintenance Checks and Services
• Table 3-1. Preventive Maintenance Checks and Services
• Table 3-1. Preventive Maintenance Checks and Services
• Table 3-1. Preventive Maintenance Checks and Services
• Table 3-1. Preventive Maintenance Checks and Services
• Table 3-1. Preventive Maintenance Checks and Services
• Table 3-1. Preventive Maintenance Checks and Services
• Section II. TROUBLESHOOTING
• Table 3-2. Troubleshooting
• MANOMETER HIGH OR LOW PRESSURE READING
• EXCESSIVE STARTING AND STOPPING OF AIR COMPRESSOR
• BATH DRAIN HAS BEEN OPENED BUT WATER DOES NOT RUN OUT
• REFRIGERATOR EVAPORATOR OR COILS WITH EXCESSIVE FROST BUILDUP
• CHAPTER 4 ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
• Figure 4-1. Types of Multimeters
• Figure 4-2. Zeroing the AN/URM-105 Meter (Sheet 1 of 3)
• Figure 4-2. Zeroing the TS-352B/U (Sheet 2 of 3)
• Figure 4-2. Zeroing the Simpson 160 (Sheet 3 of 3).
• Figure 4-3. TS-352 Continuity Test
• Figure 4-4. Testing for Shorts.
• Figure 4-5. Testing Resistance
• Figure 4-6. Reading the Ohm Scale.
• Figure 4-7. DC Volts Scale (AN/URM-105) (Sheet 1 of 3).
• Figure 4-7. DC Volts Scale (TS-352B/U) (Sheet 2 of 3).
• Figure 4-7. DC Volts Scale (Simpson 160) (Sheet 3 of 3)
• Figure 4-8. Measuring DC Voltage.
• Figure 4-9. Reading DC Voltage (Simpson 160).
• Figure 4-10. Reading DC Voltage (TS-352B/U).
• Figure 4-11. AC Volt Scale (AN/URM-105).
• Figure 4-13. AC Volt Scale (TS-352B/U)
• Figure 4-14. AC Volt Scale (Simpson 160)
• Figure 4-15. Measuring AC Voltage.
• Table 4-1. Oven Troubleshooting Chart
• Heater bank
• MANOMETER
• Table 4-2. Manometer Troubleshooting Chart
• Before Operation Service
• Table 4-3. Vacuum Pump Troubleshooting Chart
• CHAPTER 4 DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE INSTRUCTIONS
• Table 5-1. Air Compressor Troubleshooting Chart
• COMPRESSOR RUNNING HOT
• Figure 5-1. Muffle Furnace Disassembly.
• REID VAPOR PRESSURE BOMB BATH
• Table 5-2. Reid Vapor Pressure Bomb Bath Troubleshooting Chart
• REFRIGERATOR
• Troubleshooting
• Table 5-3. Refrigerator Troubleshooting Chart
• COMPRESSOR RUNS CONTINUOUSLY
• APPENDIX A REFERENCES
• REFERENCES cont'd
• REFERENCES cont'd
• APPENDIX B MAINTENANCE ALLOCATION CHART
• COLUMN ENTRIES USED IN THE MAC.
• COLUMN ENTRIES USED IN TOOL AND TEST EQUIPMENT REQUIREMENTS
• Section II. MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART
• Section III. TOOL AND TEST EQUIPMENT REQUIREMENTS
• Section IV. REMARKS
• APPENDIX C COMPONENTS OF END ITEMS LIST
• EXPLANATION OF COLUMNS cont'd
• Table
• Table
• Table
• Table
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• Section II. COMPONENTS OF END ITEMS
• APPENDIX D TEXTBOOK LISTING FOR PETROLEUM BASE LABORATORY
• TEXTBOOK LISTING FOR PETROLEUM BASE LABORATORY
• INDEX
• INDEX - Continued
• INDEX - Continued
• The Metric System and Equivalents
• TM-5-6640-214-14
• Blank Page
• DISTRIBUTION
• Recommended Changes to Equipment Technical Publications

Privacy Statement - Press Release - Copyright Information. - Contact Us