TM-5-6640-213-14

• Operator, Organizational, Direct Support and General Support Maintenance Manual
• Warning
• Warning
• Warning
• Table of Contents
• LIST OF ILLUSTRATIONS
• LIST OF ILLUSTRATIONS (Continued)
• LIST OF TABLES
• Chapter 1 INTRODUCTION
• ADMINISTRATIVE STORAGE
• Section II. DESCRIPTION AND DATA
• Figure 1-2. Rear Three-Quarter View of Airmobile Aviation Fuel Laboratory
• Utility Equipment
• Figure 1-3. Cutaway Drawing Showing Location of Equipment, Apparatus, Cabinets and Drawers on the Left Side of the Laboratory
• Figure 1-3. Cutaway Drawing Showing Location of Equipment, Apparatus, Cabinets and Drawers on the Right Side of the Laboratory
• Figure 1-5. Inetrior View of Front of Laboratory
• Figure 1-6 Interior View of Rear of Laboratory.
• TABULATED DATA.
• TABULATED DATA cont'd
• Figure 1-7. Electrical System, Wiring Diagram (Sheet 1 of 2)
• Figure 1-7. Electrical System, Wiring Diagram (Sheet 2 of 2)
• Blank Page
• CHAPTER 2 OPERATING INSTRUCTIONS
• OPERATION UNDER USUAL CONDITIONS.
• Figure 2-1. Location of Leveling Devices and Key.
• Laboratory and Equipment cont'd
• Water Supply Connection
• Utility Equipment and Water System
• Figure 2-2. Main Power Control Panel
• Figure 2-3. Water System.
• Pressure switch
• Operating Instructions cont'd
• Utility Equipment and Air System
• Tank
• Figure 2-4. Air System
• Automatic Combustible Gas Alarm and Air-Purging Systems
• Amber Warn Light
• Initial Startup Adjustments
• Air-Purging  System
• Figure 2-5. Exhaust Fan Assembly of the Air-Purging System.
• Analytical Balance
• Operating Instructions
• Operating Instructions cont'd
• Figure 2-6. Analytical Balance
• Reid Vapor Pressure Apparatus
• Figure 2-8. Reid Vapor Pressure Apparatus
• Manometer
• Figure 2-9. Manometer
• Distillation Test Apparatus
• Figure 2-10. Distillation Test Apparatus and Copper Strip Corrosion Apparatus
• Figure 2-11. Solvent Filtering Dispenser.
• Dispenser Data
• Exposing the sample pad
• Interpreting test results
• Pensky-Martens Flashpoint Tester
• Utility Oven
• Ice Maker
• Figure 2-12.  Detector Scale Conversion Chart - Free Water Content For Selected Sample Volumes.
• Figure 2-13. Water Demineralizer Unit
• Operating Instructions
• Desiccating Cabinet
• General Safety
• Fire Prevention
• Extinguishing Fires
• Hydrogen Peroxide
• Bases
• Equipment Under Pressure of Vacuum
• Pipets
• Solvents and Solutions
• Blank Page
• CHAPTER 3 OPERATOR/ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
• Table 3-1. Preventive Maintenance Checks and Services (PMCS)
• Table 3-1. Preventive Maintenance Checks and Services (PMCS) - Continued
• Table 3-1. Preventive Maintenance Checks and Services (PMCS) - Continued
• Table 3-2. Electrical System Troubleshooting
• Table 3-2. Electrical System Troubleshooting- Continued
• COMBUSTIBLE ALARM SYSTEM FAILURE.
• O POWER TO COMBUSTIBLE ALARM SYSTEM AND RVP. BATH.
• Table 3-3. Water System Troubleshooting
• MOTOR OVERHEATS.
• PUMP FAILS TO DELIVER AIR AT PROPER PRESSURE.
• PUMP VIBRATES OR OPERATES NOISILY
• Vacuum Pump
• Figure 3-1. Fill Inlet to Marked Level with SAE 10 Lubricating Oil.
• Disassembly
• Automatic Combustible Gas Alarm
• Table 3-4. Air System Troubleshooting
• PUMP FAILS TO DELIVER AIR AT PROPER PRESSURE.
• PUMP VIBRATES OR OPERATES NOISILY.
• Element replacement
• ANALYTICAL BALANCE
• Figure 3-4. Electrical Controls in Right Front Corner of Laboratory
• Figure 3-5. Alarm System Detector and Control Unit Disassembled (Sheet 1 of 2)
• Figure 3-5. Alarm System Detector and Control Unit Disassembled (Sheet 2 of 2)
• Figure 3-6. Top View, of Analytical Balance.
• Legend
• Uncrating
• Figure 3-7. Weighing Pan and Stirrup Bearing Plate.
• Preparing the Balnce for use
• Figure 3-8. Tare Ring and Tare Boat.
• REID VAPOR PRESSURE APPARATUS.
• Operator Services
• Table 3-5. Reid Vapor Pressure Apparatus Troubleshooting
• DISTILLATION TEST APPARATUS
• Table 3-6. Manometer Troubleshooting
• SOLVENT FILTERING DISPENSER.
• PENSKY-MARTENS FLASHPOINT TESTER
• WATER DEMINERALIZER UNIT
• Section II CALIBRATION INSTRUCTIONS
• THERMOMETERS
• Calculating results
• Chapter 4 DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE INSTRUCTIONS
• Switch
• Table 4-1. Oven Troubleshooting
• PILOT LIGHT DOES NOT COME ON.
• ICE MAKER
• Figure 4-1. Ice Maker
• Changing the Holding Switch
• CLASS S WEIGHTS
• Table 4-2. Ice Maker Troubleshooting
• UNIT NEEDS DEFROSTING WEEKLY.
• ICE IS SOFT AND WET.
• ICE MAKER FAILS TO MAKE ENOUGH ICE.
• ICE MAKER MOLD IS NOT LEVEL.
• ICE MAKER IS HOOKED UP BUT NO WATER COMES IN
• DOOR PANEL DOES NOT HIT OR OPERATE DOOR SWITCH
• CUBES ON TOP OF BUCKET ARE FROSTY
• KNOCKING NOISE COMING FROM COMPRESSOR
• ICE MAKER MECHANISM IS NOT DEFROSTING AUTOMATICALLY
• COMPRESSOR RUNS CONTINUOUSLY
• ICE MAKER EJECTOR MOTOR RUNS, BUT THE EJECTOR BLADES DO NOT TURN
• After Operation Service
• Table 4-3. Reid Vapor Pressure Apparatus Troubleshooting
• VACUUM PUMP
• Figure 4-2. Use a Wrench to Remove Inlet Regulator Valve on Vacuum Side of Pump
• Cleaning Pump Vanes
• Table 4-4. Vacuum Pump Troubleshooting
• Figure 4-4. Cleaning Chemistone Filter Element With Solvent
• Figure 4-6. Drawer Removal Procedures
• Figure 4-7. Removing Attaching Hardware from Under Counter
• WATER PUMP
• Figure 4-8. Bottom View of Components in Apparatus
• Figure 4-9. Removing Setscrew and Knob from Auto-Transformer
• Figure 4-10. Tag All Wiring to Auto-Transformer.
• Figure 4-11. Location of Apparatus Connector
• Figure 4-12. Heater Board Being Lifted from Apparatus
• Figure 4-13. Heater Board Removed from Apparatus
• PURGING BLOWER (EXHAUST FAN)
• APPENDIX A REFERENCES
• REFERENCES
• APPENDIX B COMPONENTS OF END ITEM
• Quantity
• Section II. INTEGRAL COMPONENTS OF END ITEM
• Section II. INTEGRAL COMPONENTS OF END ITEM cont'd
• Section II. INTEGRAL COMPONENTS OF END ITEM cont'd
• Section II. INTEGRAL COMPONENTS OF END ITEM cont'd
• Section II. INTEGRAL COMPONENTS OF END ITEM cont'd
• Section II. INTEGRAL COMPONENTS OF END ITEM cont'd
• Section II. INTEGRAL COMPONENTS OF END ITEM cont'd
• Section II. INTEGRAL COMPONENTS OF END ITEM cont'd
• Section II. INTEGRAL COMPONENTS OF END ITEM cont'd
• Section II. INTEGRAL COMPONENTS OF END ITEM cont'd
• Section III. BASIC ISSUE ITEMS
• Figure B-1. Drawer No. 1 (18, fig. 1-3)
• Figure B-2. Cabinet No. 2 (20, fig. 1-3)
• Figure B-3. Drawer No. 3 (16, fig. 1-3)
• Figure B-4. Cabinet No. 4 (17, fig. 1-3)
• Figure B-5. Drawer No. 5 (12, fig. 1-3)
• Figure B-6. Drawer No. 6 (13, fig. 1-3)
• Figure B-7. Drawer No. 7 (14, fig. 1-3)
• Figure B-8. Drawer No. 8 (15, fig. 1-3)
• Figure B-9. Drawer No. 9 (8, fig. 1-3)
• Figure B-10. Cabinet No. 10 (11, fig. 1-3)
• Figure B-11. Drawer No. 11 (6, fig. 1-3)
• Figure B-12. Cabinet No. 12 (7, fig. 1-3) (Sheet 1 of 2)
• Figure B-12. Auxiliary Drawer of Cabinet No. 12 (7, fig. 1-3) (Sheet 2 of 2)
• Figure B-13. Cabinet No. 13 (5, fig. 1-3) (Sheet 1 of 2)
• Figure B-13. Auxiliary Drawer of Cabinet No. 13 (5, fig. 1-3) (Sheet 2 of 2)
• Figure B-14. Water Tank in Cabinet No. 16 (4, fig. 1-3)
• Figure B-14. Auxiliary Drawer of Cabinet No. 10 (4, fig. 1-3)
• Figure B-16. Drawer No. 15 (20, fig. 1-4)
• Figure B-17. Drawer No. 16 (16, fig. 1-4)
• Figure B-18. Cabinet No. 17 (17, fig. 1-4)
• Figure B-19. Drawer No. 18 ("14, fig. 1-4)
• Figure B-20. Cabinet No. 19 (15, fig. 1-4)
• Figure B-21. Drawer No. 20 (10, fig. 1-4)
• Figure B-22. Cabinet No. 21 (11, fig. 1-4)
• Figure B-23. Drawer No. 22 (6, fig. 1-4)
• Figure B-24. Cabinet No. 23 (9, fig. 1-4)
• APPENDIX C ABBREVIATIONS
• Blank Page
• Appendix D MAINTENANCE ALLOCATION CHART
• Align
• EXPLANATION OF COLUMNS IN SECTION III
• Section II. MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART (Cont)
• Section III. TOOL AND TEST EQUIPMENT REQUIREMENTS
• Section IV. REMARKS
• INDEX
• INDEX
• The Metric System and Equivalents
• Recommended Changes to Equipment Technical Manuals
• Distribution
• Recommended Changes to Equipment Technical Manuals
• Blank Page
• Blank Page
• TM-5-6640-213-14
• Blank Page
• Recommended Changes to Equipment Technical Manuals
• Blank Page
• Blank page
• Recommended Changes to Equipment Technical Manuals
• Blank Page
• Recommended Changes to Equipment Technical Manuals
• Recommended Changes to Equipment Technical Manuals
• Blank Page
• Blank page

Privacy Statement - Press Release - Copyright Information. - Contact Us